Engine

Internally lubricated parts contained within the block to include pistons, piston rings and pins, main and rod bearings, crankshaft, connecting rods, camshaft, camshaft bearings, valves, valve springs, guides and seats, reeds and reed blocks. Timing chain, gears and/or belts. Seats and gaskets of a covered component if defective.

Engine head(s), engine block and/or cylinder barrels, intake manifolds only if damaged beyond repair as a result of a mechanical breakdown of one or the above covered components

Lower Unit

Internally lubricated parts contained within the gear case. (Gear case if damaged beyond repair by a covered component). Seals and gaskets of a covered component if detective.

Jet Drive

Internally lubricated parts contained within the pump housing. (Pump housing if damaged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

Fuel Delivery

Fuel delivery pump (mechanical/diaphragm), carburetor body, air box (silencer), electric choke solenoid (enrichener). Seals and gaskets of a covered component if defective.

Electrical

Alternator/stator, voltage regulator/rectifier, engine mounted terminal blocks, engine mounted wiring harness, starter motor, starter armature, starter field windings, starter magnets, brush holder and brushes, end caps and bushings, starter drive, starter solenoid.

EFI/DFI Component Coverage

Electric fuel delivery pumps (high and low pressure), fuel injectors, fuel distributors, ECU module, throttle position sensor, manifold air temperature sender, idle speed control, mass air flow sensor, detonation/knock sensor, ignition pick-up sensor. Seals and gaskets of a covered component if defective.

Ignition

Power Pack/Switch Box, Amplifier, ignition high output coil, ignition trigger coil, spark plug wires.

Power Trim

Power trim motor, power tilt motor, power trim cylinders, including cylinder rams, cylinder seats, cylinder mounts and pivots, power trim motor actuator solenoids, power trim wiring harness, power trim master control switches, reverse lock valve, manual trim cylinder, manual trim cable, and control valve.

Controls

Shift and throttle control box parts to include: cams, eccentrics, shafts, pivots, bushings, housing, control arms/levers and knobs, shift control cable, throttle control cable, ignition switch.

Mechanical Steering

Control helm assembly, control rack and yoke assembly, power steering pump, power steering cylinder, steering wheel, steering wheel mounting hub. (Excludes cables). Seals and gaskets of a covered component if defective.

Hydraulic Steering (manual systems)

Hydraulic steering head, hydraulic steering lines, hydraulic steering cylinder, hydraulic steering flow valves, steering yoke. (Excludes cables). seals and gaskets of a covered component if defective.

Oil Injection Systems

Oil injection pump, oil pump drive gear, oil pump drive shaft, oil tank, oil tank cap, oil level sensors, oil level warning horns and lights, oil injection lines, oil injection check valves, oil injection metering system.

Engine *

Internally lubricated parts contained within the cylinder block to include: Pistons, piston rings and pins, main bearings and rod bearings, crankshaft, connecting rods, camshaft, camshaft bearings, timing chain, gears and/or belt, valves, valve springs, valve guides and seats, valve push rods, lifters, oil pump. Rocker arm cover, harmonic balancer, oil pan, engine mounts. Distributor housing, shaft and bearings. Seals and gaskets of a covered component if defective.

Diesel Engines Only *

Cylinder head bolts, air intake housing, main bearing bolts, rod bolts, rocker arms, oil cooler housing, oil filter housing, flywheel housing, pump drive gears, front covers, idler gears, balancer cover housing.

Transmission

Internally lubricated parts contained within the transmission case. (Case if damaged beyond repair by a covered component). Transmisssion mounts and oil pan. Seals and gaskets of a covered component if defective.

V-Drive

Internally lubricated parts. (Cas if damaged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

Stern Drive Upper Gear Case

Internally lubricated parts. (Case if damaged beyond repair bya covered component). Seals and gaskets of a covered component if defective.

Stern Drive Lower Unit

Internally lubricated parts. (Case if damged beyond repair by a covered component). Seals and gaskets of a covered component if defective.

Fuel Delivery *

(Including turbo chargers). Fuel injectors, fuel distributors, fuel injection pumps, ECU module, throttle position sensor, manifold absolute pressure sensor, manifold air temperature sender, idle speed control, mass air flow sensor, detonation/knock sensor, coolant sensor, ignition pick u0p sensor, fuel delivery pump, fuel pump diaphragm, flame arestor. All internally lubricated parts located within the turbo charger, housing , wastegate actuator. Seals and gaskets of a covered component if defective.

Ignition

Ignition module, ignition trigger coil, ignition high output coil, spark plug wires.

Closed Cooling System

Engine water coolant circulating pump and heat exchangers. (For closed cooling system only).

Electrical *

Alternator/stator, voltage regulator/rectifier, engine mounted terminal blocks, engine mounted wiring harness, electric choke element, starter motor, starter armature, starter field windings, starter magnets, brush holder and brushes, end caps and bushings, starter drive, starter solenoid.

Controls

Shift and throttle control box parts to include: cams, eccentrics, shafts pivots, bushings, housing, control arms/levers and knobs, shift control cable, throttle control cable, and ignition switch.

Power Steering

Steering control helm assembly, control rack and yoke assembly, power steering pump, power steering cylinder, steering wheel, steering wheel munting hub. (Excludes cables.). Seals and gaskets of a covered component if defective.

Hydraulic Steering (manual systems)

Hydraulic steering head, hydraulic steering lines, hydraulic steering cylinder, hydraulic steering flow valves. (Excludes cables). Seasls and gaskets of a covered component if defective.

Intermediate Housing

Intermediate shaft bearings, U-joints, center yoke, drive yoke, gimbal bearings, steering yoke, engine coupler. Intermediate housing/gimbal housing if damaged beyond repair bya covered component. Seals and gaskets of a covered component if defective.

Power Trim

Power trim and/or tilt motor, trim cylinders, cylinder rams, cylinder seals, cylinder mounts and pivots, trim motor actuator solenoids, trim wiring harness, trim master control switches, control valve, pump and reverse lock valve.

* REPOWER COVERAGE: Components marked with an asterisk are covered when craft is repowered with a new replacement engine installed with the original V-Drive, Transmission or Stern Drive in you current craft.